Polaris · 2023 · SPN / FMI

2023 Polaris Sportsman / Scrambler XP 1000 S fault codes

The 2023 Sportsman XP 1000 S and Scrambler XP 1000 S share a 289-entry SPN/FMI table. This page lists all 289 entries from the 2023 owner's manual (P/N 9941283) — accelerator, AWD, battery and charging, brake, engine temperature, fuel, EPS, fan, and chassis circuits.

289 OEM-listed entries SPN / FMI format Source: OEM manual

Scope note

This is the 2023 Sportsman / Scrambler XP 1000 S owner's manual (P/N 9941283). Its chapter has 291 raw table rows; 289 unique entries remain after repeated code rows are collapsed.

The 2024–2026 combined manuals and the 2026–2027 2-Up manuals publish a different 179-entry table on a separate page. Do not carry a 2023 code over to a later model year without checking the manual.

The manual uses SPN/FMI pairs. Some rows name circuits or features that are not fitted to every trim; use the code your display shows.

Table profile

This page reproduces 289 entries from the 2023 Polaris Sportsman / Scrambler XP 1000 S owner’s manual, manual P/N 9941283, and chapter 0000824030.

Rows keep the manual’s printed order, from SPN 91 / FMI 3 to SPN 516247 / FMI 4.

Every row carries an SPN/FMI pair; 111 distinct SPNs and 20 FMI values appear.

The largest FMI groups are FMI 4 (50 rows), FMI 3 (48 rows), and FMI 31 (31 rows); together they account for 45% of the table.

The most repeated SPN is 84 (Vehicle Speed Sensor) with 10 rows, followed by SPN 110 with 9 rows.

Every printed SPN/FMI pair carries one title in this table.

These counts describe the rows on this page, not every manual in the archive. The source box below lists the exact citation for every record on the page.

Full OEM table

289 entries from the 2023 Polaris Sportsman / Scrambler XP 1000 S owner's manual diagnostic table.

Filter this list 289 entries

Accelerator Position 1 2

Code	Failure mode
SPN 91FMI 3	Voltage Too High
SPN 91FMI 4	Voltage Too Low

Accelerator Position 2 4

Code	Failure mode
SPN 29FMI 0	Data Valid But Above Normal Operational Range
SPN 29FMI 2	Not Plausible
SPN 29FMI 3	Voltage Too High
SPN 29FMI 4	Voltage Too Low

Accelerator Position/Brake Position Interaction 1

Code	Failure mode
SPN 520275FMI 31	Condition Exists

Accelerator Sensor Sync Fault - Sensor Diff Exceeds Limit 1

Code	Failure mode
SPN 520308FMI 31	Condition Exists

Accessory Relay 3

Code	Failure mode
SPN 520219FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520219FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520219FMI 5	Current Below Normal Or Open Circuit

Adaptive Fuel Correction Bank 1 2

Code	Failure mode
SPN 520344FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level
SPN 520344FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

All Wheel Drive Control Circuit 3

Code	Failure mode
SPN 520207FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520207FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520207FMI 5	Current Below Normal Or Open Circuit

Alternator Power Supply Potential 6

Code	Failure mode
SPN 167FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 167FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 167FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 167FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 167FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level
SPN 167FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

Barometric Pressure Sensor 4

Code	Failure mode
SPN 108FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 108FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 108FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 108FMI 10	Abnormal Rate Of Change

Battery Charge Relay 3

Code	Failure mode
SPN 520220FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520220FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520220FMI 5	Current Below Normal Or Open Circuit

Battery Potential 2

Code	Failure mode
SPN 158FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 158FMI 4	Voltage Below Normal, Or Shorted To Low Source

Brake Switch 4

Code	Failure mode
SPN 597FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 597FMI 9	Abnormal Update Rate
SPN 597FMI 10	Abnormal Rate Of Change
SPN 597FMI 19	Received Network Data In Error

Brake Switch (1 or 2 Indeterminable) 1

Code	Failure mode
SPN 520285FMI 2	Data Erratic, Intermittent Or Incorrect

Calibration 2

Code	Failure mode
SPN 630FMI 13	Out Of Calibration
SPN 630FMI 19	Checksum/CRC Error

Camshaft Position Sensor 2

Code	Failure mode
SPN 637FMI 7	Mechanical System Not Responding Or Out Of Adjustment
SPN 637FMI 8	Abnormal Frequency Or Pulse Width Or Period

CAN 1 1

Code	Failure mode
SPN 516125FMI 9	Abnormal Update Rate

CAN1 Bus Hardware 2

Code	Failure mode
SPN 65559FMI 11	Root Cause Not Known
SPN 65559FMI 31	Condition Exists

CAN1 Bus Wiring 1

Code	Failure mode
SPN 520141FMI 31	Condition Exists

Canister Purge Valve 3

Code	Failure mode
SPN 520202FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520202FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520202FMI 5	Current Below Normal Or Open Circuit

Chassis Relay 3

Code	Failure mode
SPN 520208FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520208FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520208FMI 5	Current Below Normal Or Open Circuit

Crankshaft Position Sensor 2

Code	Failure mode
SPN 636FMI 2	Plausibility Fault
SPN 636FMI 8	Abnormal Frequency Or Pulse Width Or Period

Cruise Control Panel Switches 1

Code	Failure mode
SPN 527FMI 31	Condition Exists

Cylinder 1 Misfire 1

Code	Failure mode
SPN 65591FMI 7	Mechanical System Not Responding Or Out Of Adjustment

Cylinder 2 Misfire 1

Code	Failure mode
SPN 65592FMI 7	Mechanical System Not Responding Or Out Of Adjustment

Cylinder Misfire 1

Code	Failure mode
SPN 65590FMI 7	Mechanical System Not Responding Or Out Of Adjustment

Display Relay 1

Code	Failure mode
SPN 520522FMI 5	Current Below Normal Or Open Circuit

Drive Mode Select Switch 3

Code	Failure mode
SPN 524067FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 524067FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 524067FMI 4	Voltage Below Normal, Or Shorted To Low Source

ECU ADC Fault - No Load 1

Code	Failure mode
SPN 520306FMI 31	Condition Exists

ECU ADC Fault - Voltage 1

Code	Failure mode
SPN 520307FMI 31	Condition Exists

ECU Fault - Hardware Disruption 1

Code	Failure mode
SPN 520311FMI 31	Condition Exists

ECU Fault - ICO 1

Code	Failure mode
SPN 520309FMI 31	Condition Exists

ECU Memory 2

Code	Failure mode
SPN 628FMI 12	Bad Intelligent Device Or Component
SPN 628FMI 13	Out Of Calibration

ECU Monitoring Error 1

Code	Failure mode
SPN 520286FMI 31	Condition Exists

ECU Monitoring Error (Level 3) 1

Code	Failure mode
SPN 520287FMI 31	Condition Exists

ECU Monitoring of Injection Cut Off (Level 1) 1

Code	Failure mode
SPN 520288FMI 31	Condition Exists

ECU Monitoring of Injection Cut Off (Level 2) 1

Code	Failure mode
SPN 520289FMI 31	Condition Exists

ECU Output Supply Voltage 1 6

Code	Failure mode
SPN 3597FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 3597FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 3597FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 3597FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 3597FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level
SPN 3597FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

ECU Output Supply Voltage 2 6

Code	Failure mode
SPN 3598FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 3598FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 3598FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 3598FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 3598FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level
SPN 3598FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

ECU Output Supply Voltage 3 6

Code	Failure mode
SPN 3599FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 3599FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 3599FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 3599FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 3599FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level
SPN 3599FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

EFI Relay Control Circuit 3

Code	Failure mode
SPN 1485FMI 3	Voltage Above Normal
SPN 1485FMI 4	Voltage Below Normal
SPN 1485FMI 5	Current Below Normal Or Open Circuit

Engine Oil Pressure 6

Code	Failure mode
SPN 100FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 100FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 100FMI 5	Current Below Normal Or Open Circuit
SPN 100FMI 12	Bad Intelligent Device Or Component
SPN 100FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level
SPN 100FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

Engine Speed 6

Code	Failure mode
SPN 190FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 190FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 190FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 190FMI 7	Mechanical System Not Responding Or Out Of Adjustment
SPN 190FMI 19	Received Engine Speed Has Error
SPN 190FMI 31	Error in Engine Speed Computation

Engine Temperature Sensor 9

Code	Failure mode
SPN 110FMI 0	Engine Overheat Shutdown
SPN 110FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 110FMI 3	Voltage Too High
SPN 110FMI 4	Voltage Too Low
SPN 110FMI 10	Abnormal Rate Of Change
SPN 110FMI 15	Data Valid But Above Normal Operating Range
SPN 110FMI 16	Temperature Too High
SPN 110FMI 17	Data Valid But Below Normal Operating Range
SPN 110FMI 19	Received Network Data In Error

EPS CAN Communications Transmit Error 1

Code	Failure mode
SPN 520227FMI 2	Data Erratic, Intermittent Or Incorrect

EPS Communications Receive Data Error 2

Code	Failure mode
SPN 520226FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520226FMI 31	Condition Exists

EPS Fault Lamp Driver Circuit 1

Code	Failure mode
SPN 524085FMI 12	Bad Intelligent Device Or Component

EPS Inverter Temperature 3

Code	Failure mode
SPN 520225FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 520225FMI 12	Bad Intelligent Device Or Component
SPN 520225FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level

EPS Power Save Condition 1

Code	Failure mode
SPN 520231FMI 31	Condition Exists

EPS SEPIC Voltage Error 2

Code	Failure mode
SPN 524086FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 524086FMI 4	Voltage Below Normal, Or Shorted To Low Source

ETC Accelerator Position Sensor Correlation 1

Code	Failure mode
SPN 65613FMI 2	Data Erratic, Intermittent Or Incorrect

Fan Driver 2 3

Code	Failure mode
SPN 1557FMI 3	Voltage Above Normal
SPN 1557FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 1557FMI 5	Current Below Normal Or Open Circuit

Fan Relay Driver Circuit 3

Code	Failure mode
SPN 1071FMI 3	Voltage Above Normal
SPN 1071FMI 4	Voltage Below Normal
SPN 1071FMI 5	Current Below Normal Or Open Circuit

Front Wheel Back Drive (Active Descent System) 3

Code	Failure mode
SPN 520203FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520203FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520203FMI 5	Current Below Normal Or Open Circuit

Fuel Correction Front 2

Code	Failure mode
SPN 520204FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level
SPN 520204FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

Fuel Correction Rear 2

Code	Failure mode
SPN 520205FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level
SPN 520205FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

Fuel Level Signal 5

Code	Failure mode
SPN 96FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 96FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 96FMI 4	Voltage Too Low
SPN 96FMI 16	Data Valid But Above Normal Operating Range
SPN 96FMI 18	Data Valid But Below Normal Operating Range

Fuel Pull Solenoid Relay Driver Circuit (Low Side) 3

Code	Failure mode
SPN 520273FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520273FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520273FMI 5	Current Below Normal Or Open Circuit

Fuel Pump Driver Circuit 4

Code	Failure mode
SPN 1347FMI 3	Voltage Above Normal
SPN 1347FMI 4	Voltage Below Normal
SPN 1347FMI 5	Current Below Normal Or Open Circuit
SPN 1347FMI 8	Abnormal Frequency Or Pulse Width Or Period

Gear Sensor Signal 5

Code	Failure mode
SPN 523FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 523FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 523FMI 4	Voltage Too Low
SPN 523FMI 9	Abnormal Update Rate
SPN 523FMI 11	Root Cause Not Known

IC CAN Communication with EPS 1

Code	Failure mode
SPN 520230FMI 31	Condition Exists

Idle Engine speed 1

Code	Failure mode
SPN 516178FMI 19	Received Network Data In Error

Idle Fuel Correction Bank 1 1

Code	Failure mode
SPN 520342FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level

Idle Fuel Correction Bank 2 2

Code	Failure mode
SPN 520343FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level
SPN 520343FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

Idle Speed 2

Code	Failure mode
SPN 520211FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520211FMI 4	Voltage Below Normal, Or Shorted To Low Source

Ignition Coil Primary Driver 1 (MAG) 3

Code	Failure mode
SPN 1268FMI 3	Voltage Above Normal
SPN 1268FMI 4	Voltage Below Normal
SPN 1268FMI 5	Current Below Normal Or Open Circuit

Ignition Coil Primary Driver 2 (PTO) 3

Code	Failure mode
SPN 1269FMI 3	Voltage Above Normal
SPN 1269FMI 4	Voltage Below Normal
SPN 1269FMI 5	Current Below Normal Or Open Circuit

Injector 1 (MAG) 2

Code	Failure mode
SPN 651FMI 4	Voltage Below Normal / Shorted To Low Source / Driver Circuit Grounded.
SPN 651FMI 5	Current Below Normal / Open Circuit / Driver Circuit Open / Grounded

Injector 2 (PTO) 3

Code	Failure mode
SPN 652FMI 3	Voltage Above Normal, Or Shorted To High Source / Driver Circuit Short to B+
SPN 652FMI 4	Voltage Below Normal, Or Shorted To Low Source / Driver Circuit Grounded
SPN 652FMI 5	Current Below Normal Or Open Circuit / Driver Circuit Open / Grounded

Intake Air Pressure Sensor 5

Code	Failure mode
SPN 106FMI 0	Data Valid But Above Normal Operational Range
SPN 106FMI 1	Data Valid But Below Normal Operational Range
SPN 106FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 106FMI 3	Voltage Too High
SPN 106FMI 4	Voltage Too Low

Intake Air Temperature Sensor (T-MAP) 6

Code	Failure mode
SPN 105FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 105FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 105FMI 3	Voltage Too High
SPN 105FMI 4	Voltage Too Low
SPN 105FMI 10	Abnormal Rate Of Change
SPN 105FMI 15	Data Valid But Above Normal Operating Range

Internal fault - Chassis Output Disabled 1

Code	Failure mode
SPN 520376FMI 31	Condition Exists

Manifold Absolute Pressure Sensor 5

Code	Failure mode
SPN 102FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 102FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 102FMI 4	Voltage Too Low
SPN 102FMI 7	Mechanical System Not Responding Or Out Of Adjustment
SPN 102FMI 10	Abnormal Rate Of Change

Non Functional Application SW Installed 1

Code	Failure mode
SPN 520381FMI 31	Condition Exists

Operator Presence Switch 1

Code	Failure mode
SPN 524070FMI 3	Voltage Above Normal, Or Shorted To High Source

Oxygen Sensor Bank 1 Sensor 1 5

Code	Failure mode
SPN 3056FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 3056FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 3056FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 3056FMI 12	Bad Intelligent Device Or Component
SPN 3056FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

Oxygen Sensor Bank 1 Sensor 2 3

Code	Failure mode
SPN 3057FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 3057FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 3057FMI 4	Voltage Below Normal, Or Shorted To Low Source

Plowing In High Range 1

Code	Failure mode
SPN 516249FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level

Position Encoder Error 3

Code	Failure mode
SPN 520228FMI 11	Root Cause Not Known
SPN 520228FMI 12	Bad Intelligent Device Or Component
SPN 520228FMI 31	Condition Exists

PTO Solenoid Driver Circuit 3

Code	Failure mode
SPN 1888FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 1888FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 1888FMI 5	Current Below Normal Or Open Circuit

Rear Differential Output (Turf) 3

Code	Failure mode
SPN 746FMI 3	Driver Circuit Short to B+
SPN 746FMI 4	Driver Circuit Grounded
SPN 746FMI 5	Driver Circuit Open / Grounded

Reverse Alarm 4

Code	Failure mode
SPN 520206FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520206FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520206FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520206FMI 5	Current Below Normal Or Open Circuit

Software Error 2

Code	Failure mode
SPN 520229FMI 12	Bad Intelligent Device Or Component
SPN 520229FMI 31	Condition Exists

Starter Enable Circuit 3

Code	Failure mode
SPN 1321FMI 3	Voltage Above Normal
SPN 1321FMI 4	Voltage Below Normal
SPN 1321FMI 5	Current Below Normal Or Open Circuit

Starter Solenoid Driver Circuit 3

Code	Failure mode
SPN 677FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 677FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 677FMI 5	Current Below Normal Or Open Circuit

Stator 2

Code	Failure mode
SPN 520498FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520498FMI 5	Current Below Normal Or Open Circuit

Steering Excessive Current Error 1

Code	Failure mode
SPN 520222FMI 6	Current Above Normal Or Grounded Circuit

Steering Over Current Shut Down 2

Code	Failure mode
SPN 520221FMI 6	Current Above Normal Or Grounded Circuit
SPN 520221FMI 12	Bad Intelligent Device Or Component

Steering Torque Full Failure 1

Code	Failure mode
SPN 520224FMI 31	Condition Exists

Steering Torque Partial Failure 1

Code	Failure mode
SPN 520223FMI 31	Condition Exists

System Power 7

Code	Failure mode
SPN 168FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 168FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 168FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 168FMI 3	Voltage Too High
SPN 168FMI 4	Voltage Too Low
SPN 168FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level
SPN 168FMI 18	Data Valid But Below Normal Operating Range - Moderately Severe Level

System Voltage 2

Code	Failure mode
SPN 627FMI 15	Data Valid But Above Normal Operating Range - Least Severe Level
SPN 627FMI 17	Data Valid But Below Normal Operating Range - Least Severe Level

Throttle Body Control 3

Code	Failure mode
SPN 520283FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520283FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520283FMI 4	Voltage Below Normal, Or Shorted To Low Source

Throttle Body Control - Adaption Aborted 1

Code	Failure mode
SPN 520279FMI 31	Condition Exists

Throttle Body Control - Limp Home Position Check Failed 1

Code	Failure mode
SPN 520280FMI 31	Condition Exists

Throttle Body Control - Mechanical Stop Adaptation Failure 1

Code	Failure mode
SPN 520281FMI 31	Condition Exists

Throttle Body Control - Position Deviation Fault 1

Code	Failure mode
SPN 520284FMI 31	Condition Exists

Throttle Body Control - Power Stage 5

Code	Failure mode
SPN 520277FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520277FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520277FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520277FMI 8	Abnormal Frequency Or Pulse Width Or Period
SPN 520277FMI 31	Condition Exists

Throttle Body Control - Repeated Adaptation Failed 1

Code	Failure mode
SPN 520282FMI 31	Condition Exists

Throttle Body Control - Requested Throttle Angle Not Plausible 1

Code	Failure mode
SPN 520305FMI 31	Condition Exists

Throttle Body Control - Return Spring Check Failed 1

Code	Failure mode
SPN 520278FMI 31	Condition Exists

Throttle Position Sensor (1 or 2 Indeterminable) 2

Code	Failure mode
SPN 520276FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520276FMI 12	Bad Intelligent Device Or Component

Throttle Position Sensor 1 7

Code	Failure mode
SPN 51FMI 0	Data Valid But Above Normal Operational Range
SPN 51FMI 1	Data Valid But Below Normal Operational Range
SPN 51FMI 2	Signal Out of Range
SPN 51FMI 3	Voltage Too High
SPN 51FMI 4	Voltage Too Low
SPN 51FMI 10	Abnormal Rate Of Change
SPN 51FMI 13	Out Of Calibration

Throttle Position Sensor 2 6

Code	Failure mode
SPN 520198FMI 0	Data Valid But Above Normal Operational Range - Most Severe Level
SPN 520198FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 520198FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520198FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520198FMI 10	Abnormal Rate Of Change
SPN 520198FMI 13	Out Of Calibration

Throttle Release Signal 4

Code	Failure mode
SPN 520194FMI 2	Data Erratic, Intermittent Or Incorrect
SPN 520194FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 520194FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 520194FMI 7	Mechanical System Not Responding Or Out Of Adjustment

Transmission Range 1

Code	Failure mode
SPN 162FMI 2	Invalid

Transmission Requested Gear 1

Code	Failure mode
SPN 525FMI 19	Received Network Data In Error

Vehicle Speed 1

Code	Failure mode
SPN 2590FMI 16	Data Valid But Above Normal Operating Range - Moderately Severe Level

Vehicle Speed Sensor 10

Code	Failure mode
SPN 84FMI 0	Data Valid But Above Normal Operational Range
SPN 84FMI 1	Data Valid But Below Normal Operational Range
SPN 84FMI 2	Data Erratic or Intermittent (or missing)
SPN 84FMI 3	Voltage Too High
SPN 84FMI 4	Voltage Below Normal, Or Shorted To Low Source
SPN 84FMI 8	Abnormal Frequency Or Pulse Width Or Period
SPN 84FMI 9	Abnormal Update Rate
SPN 84FMI 10	Abnormal Rate Of Change
SPN 84FMI 12	Bad Intelligent Device Or Component
SPN 84FMI 19	Received Vehicle Speed Has Error

Winch Auto Stop Signal 1

Code	Failure mode
SPN 516248FMI 4	Voltage Below Normal, Or Shorted To Low Source

Winch In Commanded State 3

Code	Failure mode
SPN 516246FMI 1	Data Valid But Below Normal Operational Range - Most Severe Level
SPN 516246FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 516246FMI 4	Voltage Below Normal, Or Shorted To Low Source

Winch Out Commanded State 2

Code	Failure mode
SPN 516247FMI 3	Voltage Above Normal, Or Shorted To High Source
SPN 516247FMI 4	Voltage Below Normal, Or Shorted To Low Source

Source: Polaris Owner's Manual P/N 9941283 (2023 Sportsman / Scrambler XP 1000 S) - Diagnostic Display Code Definitions. Codes can vary by trim, market, and running changes.

What the FMI number means

Every entry above pairs an SPN with an FMI. The FMI is the failure type; the SPN is the circuit or component.

FMI = failure mode identifier. The same FMI means the same type of failure across sensors.
FMI	What it generally means
0	Data valid, but above the normal operating range (most severe)
1	Data valid, but below the normal operating range (most severe)
2	Data erratic, intermittent, or incorrect
3	Voltage above normal, or shorted to a high source
4	Voltage below normal, or shorted to a low source
5	Current below normal, or open circuit
6	Current above normal, or grounded circuit
7	Mechanical system not responding or out of adjustment
8	Abnormal frequency, pulse width, or period
9	Abnormal update rate
10	Abnormal rate of change
11	Root cause not known
12	Bad intelligent device or component
13	Out of calibration
16	Data valid, but above the normal operating range (moderately severe)
19	Received network data in error
31	Condition exists (manufacturer-specific)

Reading the table

The code column gives the identifier the controller publishes: an SPN/FMI pair or a P-code. The label column gives the short condition or component/failure text from the cited OEM chapter.

A label identifies a monitored circuit or condition. It does not confirm that a named part has failed, and it does not establish whether the machine is safe to operate.

Write down the full code, the model year and model, and the conditions when it appears. That record is what the manual and a service provider use to match the entry to your machine.

Source note

This page publishes short labels from the public OEM owner's manual chapter, not the manual's long-form repair prose. The source box below gives the exact chapter and model-year coverage.

Scope

This is a label index. It does not provide repair procedures, parts advice, or a diagnosis for a specific machine. Codes can vary by trim, market, and running changes.

Common questions

What does this 2023 Polaris Sportsman / Scrambler XP 1000 S table cover?

This page lists 289 code entries from the cited public OEM chapter (Polaris Owner's Manual P/N 9941283 (2023 Sportsman / Scrambler XP 1000 S) - Diagnostic Display Code Definitions). The table preserves the short condition or component/failure labels published in that chapter.

Where can I check the source?

The source box at the bottom of the page gives the manual P/N, the model-year coverage, and a link to the OEM chapter. The methodology page explains the site’s source and labeling rules.

Code decoderSearch all published models by SPN/FMI or P-code. How to read Polaris codesSPN/FMI vs P-codes, code states, and how to record an entry. All Polaris coverageBrowse every published model-year page. 2024 Sportsman / Scrambler XP 1000 S179 OEM-listed entries 2025 Sportsman / Scrambler XP 1000 S179 OEM-listed entries 2026 Sportsman / Scrambler XP 1000 S179 OEM-listed entries